Forum: Modifications
07-19-2021, 06:33 AM
|
Replies: 10
Views: 976
|
Forum: Modifications
07-17-2021, 10:01 PM
|
Replies: 10
Views: 976
|
Forum: Modifications
07-17-2021, 08:31 PM
|
Replies: 10
Views: 976
|
Forum: Modifications
07-14-2021, 04:34 PM
|
Replies: 10
Views: 976
The beauty of this setup is the ability to use...
The beauty of this setup is the ability to use the bike rack on the truck, once we arrive at our destination. Or remove it completely if we don’t need it for a certain trip. The bumper is so solid...
|
Forum: Modifications
07-14-2021, 04:33 PM
|
Replies: 10
Views: 976
Two more problems to solve. First, my Kuat NV...
Two more problems to solve. First, my Kuat NV 2.0 Three bike rack isn’t rated for the back of an RV. So my solution is to give it more support. I dabbed up an additional cradle to support and...
|
Forum: Modifications
07-14-2021, 04:31 PM
|
Replies: 10
Views: 976
PICTURE 1: When everything was test fit on the...
PICTURE 1: When everything was test fit on the camper, I tacked the frame extension to them bumper and removed the whole assembly for better welding position. I suck at welding in perfect position,...
|
Forum: Modifications
07-14-2021, 04:26 PM
|
Replies: 10
Views: 976
PICTURE 1: Bumper test fit - looks good
...
PICTURE 1: Bumper test fit - looks good
PICTURE 2: A better look of the frame extensions - rounded the corners off & drilled bolt holes.
PICTURE 3: Welded 1/8” x 1-1/2 flat stock inside the...
|
Forum: Modifications
07-14-2021, 04:23 PM
|
Replies: 10
Views: 976
Upgraded Bumper and Bike Rack
I’ve been trying to figure out how and where to store our bikes while traveling. Front of truck, top of truck, tongue of camper, in the truck, in the camper, or back of the camper Once we decided...
|
Forum: Modifications
09-23-2020, 10:43 PM
|
Replies: 12
Views: 1,346
After filling the tank fully and leaving it...
After filling the tank fully and leaving it overnight, the tank sagged enough to actually rest on the axle. Now it did cross my mind, that the axle tube might be just fine to support a bit of weight...
|
Forum: Sunline Travel Trailers
09-22-2020, 03:33 PM
|
Replies: 3
Views: 1,041
Blue and silver lever is the pressure release...
Blue and silver lever is the pressure release safety valve. It just protects the hot water heater from expansion.
The two lines under the bathroom sink are your low point drains. They will...
|
Forum: Modifications
09-21-2020, 08:55 AM
|
Replies: 12
Views: 1,346
Holy cowl! That angle iron must be more like...
Holy cowl! That angle iron must be more like angle sheet metal lol. Well my 1/8"x2x2 angle on one side and 1/8x2x3 on the other won't buckle, but the belly out will definitely won't happen. To what...
|
Forum: Modifications
09-20-2020, 09:54 PM
|
Replies: 23
Views: 2,050
I don't love how close together the the jack...
I don't love how close together the the jack posts are. That's clearly the weak point. We're camping this weekend and will be the trial run with it. It ought to be pretty clear right away if...
|
Forum: Modifications
09-20-2020, 09:25 PM
|
Replies: 12
Views: 1,346
|
Forum: Modifications
09-20-2020, 09:24 PM
|
Replies: 12
Views: 1,346
I bought the ripple and smooth combo. I agree,...
I bought the ripple and smooth combo. I agree, I've resorted to silicone in the past with the ripple only. Even still, I use double pipe clamps. I also noticed today, that I poked a little hope in...
|
Forum: Modifications
09-20-2020, 09:06 PM
|
Replies: 12
Views: 1,346
I had an issue I wondering about before I...
I had an issue I wondering about before I started. The 3 way valve (https://www.amazon.com/gp/product/B000EDQQCE/ref=ppx_yo_dt_b_asin_title_o01_s00?ie=UTF8&psc=1) (pic with the single valve) I used...
|
Forum: Modifications
09-19-2020, 11:46 PM
|
Replies: 23
Views: 2,050
|
Forum: Modifications
09-19-2020, 11:06 PM
|
Replies: 9
Views: 1,703
I just posted my addition of a 2nd water tank...
I just posted my addition of a 2nd water tank here (https://www.sunlineclub.com/forums/f65/added-a-2nd-water-tank-19888.html#post153917).
I bought my tank from RecPro and they have many sizes,...
|
Forum: Modifications
09-19-2020, 11:02 PM
|
Replies: 12
Views: 1,346
|
Forum: Modifications
09-19-2020, 10:57 PM
|
Replies: 12
Views: 1,346
Added a 2nd water tank
After installing a new axle (https://www.sunlineclub.com/forums/f71/another-axle-upgrade-thread-19707.html) I gained 2" more inches of space above the axle. Perfect spot for a 2nd fresh water tank....
|
Forum: Repairs and Maintenance
06-16-2020, 06:46 AM
|
Replies: 10
Views: 1,161
Thanks Tod. I've been up to Alaska many times...
Thanks Tod. I've been up to Alaska many times and driven it once back in the 90's. Lived there for one winter too. It must feel like winter (except for the cold and dark) up there to them with so...
|
Forum: Repairs and Maintenance
06-16-2020, 06:42 AM
|
Replies: 10
Views: 1,161
|
Forum: Repairs and Maintenance
06-15-2020, 04:09 PM
|
Replies: 6
Views: 1,212
|
Forum: Testing Area
06-14-2020, 12:58 PM
|
Replies: 8
Views: 1,077
|
Forum: Testing Area
06-14-2020, 12:18 PM
|
Replies: 8
Views: 1,077
|
Forum: Repairs and Maintenance
06-14-2020, 11:55 AM
|
Replies: 10
Views: 1,161
|
Forum: Repairs and Maintenance
06-14-2020, 09:08 AM
|
Replies: 10
Views: 1,161
|
Forum: Repairs and Maintenance
06-14-2020, 09:04 AM
|
Replies: 10
Views: 1,161
|
Forum: Repairs and Maintenance
06-14-2020, 09:02 AM
|
Replies: 10
Views: 1,161
Here are a few of the A-frame reinforcement. I...
Here are a few of the A-frame reinforcement. I know Sunline had a few models that had A-frame and header issues. This camper used such light materials that I felt I would have issues eventually. I...
|
Forum: Repairs and Maintenance
06-14-2020, 08:48 AM
|
Replies: 10
Views: 1,161
|
Forum: Repairs and Maintenance
06-14-2020, 08:38 AM
|
Replies: 10
Views: 1,161
I unbolted and cut off the old Lippert torsion...
I unbolted and cut off the old Lippert torsion 4400lb axle plates, build a 2x2 (1/4 wall) rectangle frame to raise the new axle up. I ordered a 5500lb rated Dexter Torflex axle with Nver adjust...
|
Forum: Repairs and Maintenance
06-14-2020, 08:26 AM
|
Replies: 10
Views: 1,161
Another Axle Upgrade Thread
It's been awhile since I've posted and sadly, I'm no longer a Sunline owner. We sold our 3rd Sunline this spring in favor of a new smaller 2020 Forest River camper that would be more maneuverable...
|
Forum: Sunlines For Sale
03-10-2020, 10:16 PM
|
Replies: 8
Views: 1,478
Sold
SOLD
Thanks. She was a great camper. Lots of great memories. On to the next...
|
Forum: Sunlines For Sale
03-04-2020, 04:41 AM
|
Replies: 8
Views: 1,478
|
Forum: Sunlines For Sale
03-03-2020, 06:31 PM
|
Replies: 8
Views: 1,478
|
Forum: Sunlines For Sale
02-29-2020, 04:03 PM
|
Replies: 8
Views: 1,478
|
Forum: Sunlines For Sale
02-29-2020, 03:59 PM
|
Replies: 8
Views: 1,478
|
Forum: Sunlines For Sale
02-29-2020, 08:55 AM
|
Replies: 8
Views: 1,478
|
Forum: Sunlines For Sale
02-29-2020, 08:53 AM
|
Replies: 8
Views: 1,478
|
Forum: Repairs and Maintenance
11-18-2019, 07:58 AM
|
Replies: 9
Views: 1,608
Yes I can at least put eyes one that bundle and...
Yes I can at least put eyes one that bundle and don't see any signs of damage there. I'm going to start by running a pair of wires out the door and around the outside to the furnace and make sure it...
|
Forum: Repairs and Maintenance
11-17-2019, 09:11 PM
|
Replies: 9
Views: 1,608
Thanks John. When I jump the blues at the...
Thanks John. When I jump the blues at the furnace, The fan comes on, ~15 seconds later the furnace sparks & ignites and burns until I remove the jumper. When I remove the jumper, the flame goes out...
|
Forum: Repairs and Maintenance
11-17-2019, 11:04 AM
|
Replies: 9
Views: 1,608
|
Forum: Repairs and Maintenance
11-17-2019, 08:41 AM
|
Replies: 9
Views: 1,608
A strange development I forgot to mention....on...
A strange development I forgot to mention....on the evening after replacing the board on the furnace (with no change), in the middle of the night the furnace fan turned on. No spark or gas though. ...
|
Forum: Repairs and Maintenance
11-17-2019, 08:36 AM
|
Replies: 9
Views: 1,608
|
Forum: Repairs and Maintenance
11-17-2019, 07:06 AM
|
Replies: 9
Views: 1,608
Furnace not working
I brought my camper to my upper Michigan hunting camp in early October, used the furnace and everything was fine. I returned a couple weeks later on a cold Friday night and the furnace would not...
|
Forum: Modifications
09-20-2015, 05:54 AM
|
Replies: 14
Views: 3,788
|
Forum: Modifications
09-19-2015, 07:51 PM
|
Replies: 14
Views: 3,788
|
Forum: Sunline Community
07-17-2014, 07:41 AM
|
Replies: 22
Views: 3,619
This is something that is rising higher on my...
This is something that is rising higher on my "wish list" after a recent experience at an RV park in CO....We got back to the camper in the afternoon and kicked the AC on, when it started briefly...
|
Forum: Modifications
07-03-2014, 05:24 AM
|
Replies: 13
Views: 2,315
|
Forum: Modifications
07-03-2014, 05:17 AM
|
Replies: 17
Views: 5,082
|
Forum: Modifications
06-30-2014, 10:41 PM
|
Replies: 17
Views: 5,082
Here's what you are looking for...
Leaf...
Here's what you are looking for...
Leaf Springs
https://www.practical-fishing-tips.com/image-files/boat-trailer-springs-7.jpg
Torsion Axles (rubber spring inside the axle)
...
|